Clutchless multi-speed transmission for EVs

Transmission specialist Zeroshift has devised a multi-speed gearbox for electric vehicles (EVs) that needs no clutch.
February 1, 2012 Read time: 1 min
Zeroshift's multi-speed transmission concept changes gear without interrupting the torque, allowing EVs to run for longer at peak efficiency.

Transmission specialist 1994 Zeroshift has devised a multi-speed gearbox for electric vehicles (EVs) that needs no clutch. A damper inside the gear hubs and electronic control of the motor make ratio changes seamless. The company claims the innovation could enable manufacturers to downsize EVs’ electric motors, keeping them running longer at the medium loads and speeds where peak efficiency of over 95 per cent is possible. For drivers, that could mean more performance, greater range and longer lasting batteries.

Zeroshift’s managing director Bill Martin says: “Our studies suggest that by using a compact, multi-speed transmission and a smaller electric motor, manufacturers can gain an operating efficiency of up to 10 per cent. You can use that 10 per cent to improve EVs’ range or reduce the size, weight and cost of battery packs.”

Zeroshift’s concept prevents any torque interruptions during ratio changes and does not require a clutch, issues that have so far deterred EV manufacturers from fitting multi-speed gearboxes. Current EVs instead use a single-speed transmission, but the motor then spends more of its time outside of its optimum efficiency range.

Related Content

  • December 20, 2016
    Electric vehicles in construction are the future, say researchers
    The industrial and commercial sector is the largest part of the electric vehicle value market and that will continue to be the case according to analysis in the IDTechEx report, Industrial and Commercial Electric Vehicles 2017-2027. Buses are the largest part of that and they are mainly made in China for China, where typical orders are ten times the size of orders elsewhere. Less dramatically, construction, mining and agriculture do not see 70 per cent grants for EV versions yet they are steadily becomin
    Read More
  • May 17, 2012
    Future EV owners can make money from the power grid
    In what is being claimed as a landmark research report published by Ricardo and National Grid in the UK, the market potential is demonstrated for an electric plug-in vehicle fleet of the future to provide balancing services to the power grid on a commercial basis, returning value to vehicle owners while improving the carbon efficiency of grid operation.
    Read More
  • February 1, 2012
    IP technology the route to efficient multi-agency control rooms
    As IP-based technology makes its presence felt in the control room sector, it makes for greater economies of scale and also offers a migration path for many other traffic management technologies. So says Barco's Guy Van Wijmeersch. Efficient control room collaboration and decision-making is only possible if operators and decision-makers have easy and timely access to information. In many cases, that information also needs to be accessible to multiple users at the same time. This is certainly so in the case
    Read More
  • October 27, 2016
    The downside of driverless vehicles
    Driverless cars will have a detrimental effect on congestion and security while the road safety benefits can be achieved sooner and cheaper using ADAS, argues Colin Sowman. Many Governments are consulting about the introduction of driverless vehicles and even running trials. As 70% or 80% of crashes are caused by human error, the promise of a crash-free future of driverless, self-driving or autonomous vehicles (call them what you will) is alluring, as are the claims of reduced congestion and lower emissions
    Read More

Highlighted Content