Clutchless multi-speed transmission for EVs

Transmission specialist Zeroshift has devised a multi-speed gearbox for electric vehicles (EVs) that needs no clutch.
February 1, 2012 Read time: 1 min
Zeroshift's multi-speed transmission concept changes gear without interrupting the torque, allowing EVs to run for longer at peak efficiency.

Transmission specialist 1994 Zeroshift has devised a multi-speed gearbox for electric vehicles (EVs) that needs no clutch. A damper inside the gear hubs and electronic control of the motor make ratio changes seamless. The company claims the innovation could enable manufacturers to downsize EVs’ electric motors, keeping them running longer at the medium loads and speeds where peak efficiency of over 95 per cent is possible. For drivers, that could mean more performance, greater range and longer lasting batteries.

Zeroshift’s managing director Bill Martin says: “Our studies suggest that by using a compact, multi-speed transmission and a smaller electric motor, manufacturers can gain an operating efficiency of up to 10 per cent. You can use that 10 per cent to improve EVs’ range or reduce the size, weight and cost of battery packs.”

Zeroshift’s concept prevents any torque interruptions during ratio changes and does not require a clutch, issues that have so far deterred EV manufacturers from fitting multi-speed gearboxes. Current EVs instead use a single-speed transmission, but the motor then spends more of its time outside of its optimum efficiency range.

Related Content

  • February 2, 2012
    Governments must look beyond short-term spending of public funds
    Phil Pettitt, Chief Executive of innovITS, the UK's ITS Centre of Excellence, argues that governments need to look beyond the short-term when looking to pump-prime economic recovery with public funds. It seems, in the current economic climate, that a 'good' day is one in which no company is announcing job cuts or going into administration. Consumer demand is down and businesses are retrenching, cutting costs and fretting over the consequences of shrinking opportunities and order books. It has not been this
    Read More
  • April 17, 2012
    IBM, Honda, and PG&E enable smarter charging for EVs
    IBM has teamed with American Honda Motor Company and Pacific Gas and Electric Company on a new pilot project that will allow communication between electric vehicles (EVs) and the power grid. This project will demonstrate and test an electric vehicle's ability to receive and respond to charge instructions based on the grid condition and the vehicle's battery state. With visibility into charging patterns, energy providers will have the ability to more effectively manage charging during peak hours and create c
    Read More
  • March 1, 2021
    CES 2021 | Connecting cities
    Covid-19 forced the Las Vegas Convention Center to close its doors for CES 2021, but the trade show’s online debut suggests the pandemic is helping cities
    Read More
  • April 20, 2012
    The afterlife of spent electric vehicle batteries
    Earlier this year, General Motors signed a definitive agreement with ABB Group to identify joint research and development projects that would reuse Chevrolet Volt battery systems, which will have up to 70 per cent of life remaining after their automotive use is exhausted. Recent research conducted by GM predicts that secondary use of 33 Volt batteries will have enough storage capacity to power up to 50 homes for about four hours during a power cut.
    Read More

Highlighted Content