Unique air shutter improves fuel efficiency

General Motors has revealed a new innovation behind the front grill of its Chevrolet Cruze Eco model where an automatic air shutter system allows the car to change shape and cut through the air more smoothly.
February 1, 2012 Read time: 1 min

948 General Motors has revealed a new innovation behind the front grill of its 1960 Chevrolet Cruze Eco model where an automatic air shutter system allows the car to change shape and cut through the air more smoothly.

The air shutter system uses sensors to feel and sense wind and temperature conditions. The sensors are married to electric motors that open and close the shutters automatically. With the shutters closed at high speeds, wind drag is reduced. At lower speeds, the shutters open to maximise engine-cooling air flow. Chevrolet says the air shutter system contributes nearly half a mile per gallon in combined city and highway driving.

The cooling systems for all GM vehicles are designed for the worst-case scenario, which is pulling a trailer up a grade in Death Valley. The shutter allows them to significantly improve fuel economy, while still providing the cooling needed in that extreme case.

For more information on companies in this article

Related Content

  • US traffic deaths up 7.7 per cent in 2015
    July 8, 2016
    Preliminary data released by the US Department of Transportation’s National Highway Traffic Safety Administration (NHTSA) show a 7.7 per cent increase in motor vehicle traffic deaths in 2015. An estimated 35,200 people died in 2015, up from the 32,675 reported fatalities in 2014. Although the data are preliminary and requires additional analysis, the early NHTSA estimate shows 9 out of 10 regions within the United States had increased traffic deaths in 2015. The most significant increases came for pedest
    Read More
  • Data helps Ohio DoT get grant money
    January 25, 2022
    Ohio Department of Transportation turned to StreetLight Data when it needed to finalise grant money for a key infrastructure link. David Crawford sees how metrics brought in the cash…
    Read More
  • Nine in 10 people want tougher sentences for drivers who kill
    July 11, 2016
    A study to mark the launch of Brake’s new Roads to Justice Campaign shows there is huge support for strengthening both the charges and sentences faced by criminal drivers. Ninety-one per cent of people questioned agreed that if someone causes a fatal crash when they get behind the wheel after drinking or taking drugs, they should be charged with manslaughter. That carries a possible life sentence. At present people can either be charged with causing death by dangerous driving or causing death by careless
    Read More
  • ASECAP examines tolling’s trials, tribulations and triumphs
    September 4, 2018
    If you want to get up to speed on the main issues facing the transport sector and tolling companies, ASECAP Study Days event in Ljubljana was a good place to start. Colin Sowman reports (Photographs: Louis David). Increasing populations, ever-higher technical and safety requirements, and electric and hybrid vehicles will provide both challenges and opportunities for tolling companies. The annual Study Days event organised by ASECAP (the European association for tolling companies) examined all of these aspec
    Read More

Highlighted Content