Unique air shutter improves fuel efficiency

General Motors has revealed a new innovation behind the front grill of its Chevrolet Cruze Eco model where an automatic air shutter system allows the car to change shape and cut through the air more smoothly.
February 1, 2012 Read time: 1 min

948 General Motors has revealed a new innovation behind the front grill of its 1960 Chevrolet Cruze Eco model where an automatic air shutter system allows the car to change shape and cut through the air more smoothly.

The air shutter system uses sensors to feel and sense wind and temperature conditions. The sensors are married to electric motors that open and close the shutters automatically. With the shutters closed at high speeds, wind drag is reduced. At lower speeds, the shutters open to maximise engine-cooling air flow. Chevrolet says the air shutter system contributes nearly half a mile per gallon in combined city and highway driving.

The cooling systems for all GM vehicles are designed for the worst-case scenario, which is pulling a trailer up a grade in Death Valley. The shutter allows them to significantly improve fuel economy, while still providing the cooling needed in that extreme case.

For more information on companies in this article

Related Content

  • Adaptive cruise control can mitigate phantom traffic jams, says Ford
    July 10, 2018
    Phantom traffic jams can be minimised through adaptive cruise control (ACC) technology, says Ford. These traffic jams occur when one driver hits the brakes and causes a chain reaction of other drivers tapping their brakes which causes traffic flow to halt. Ford conducted a test alongside Vanderbilt University researchers on a closed test track involving 36 vehicles across three lanes. https://www.youtube.com/watch?v=2GYfXxVn2Oc The motor company says the main causes of phantom jams are human fa
    Read More
  • Mounting benefits of dynamic tolling project
    January 30, 2012
    Wisconsin's four-year HOT lanes pilot project, launched in May 2008, cost US$18.8 million to construct. Halfway into the project, which uses variably priced, or dynamic, tolling to improve highway efficiency, the benefits are mounting. The problem was obvious, and frustrating, to anyone who ever sat in bumper-to-bumper traffic on State Route 167 and watched a lone car whiz by every 20 seconds or so in the carpool lane. But for planners at the Washington State Department of Transportation, the conundrum was
    Read More
  • Progressing work zone safety systems
    February 1, 2012
    David Crawford investigates progress in a key safety area - work zones. Highway construction zone safety is taken seriously enough in the US to merit a special spring National Work Zone Awareness Week, which in 2010 ran from 19-23 April. Headed by the US Department of Transportation's Federal Highway Administration (FHWA), this aims to reduce an annual toll of work zone deaths - 720 in 2008 (an average of one every 10 hours) with more than 40,000 traffic injuries (an average of one every 13 minutes).
    Read More
  • Progressing work zone safety systems
    February 6, 2012
    David Crawford investigates progress in a key safety area - work zones
    Read More

Highlighted Content