Shell consortium plans bulk hydrogen production project

A consortium of Shell Deutschland Oil and Shell Energy Europe with partners ITM Power, SINTEF, thinkstep and Element Energy plans a project to install a large scale electrolyser to produce hydrogen at the Wesseling refinery site within the Rheinland Refinery Complex. With a capacity of ten megawatts, this would be the largest unit of its kind in Germany and the world’s largest PEM (Polymer Electrolyte Membrane) electrolyser.
September 4, 2017 Read time: 2 mins

A consortium of Shell Deutschland Oil and Shell Energy Europe with partners ITM Power, SINTEF, thinkstep and Element Energy plans a project to install a large scale electrolyser to produce hydrogen at the Wesseling refinery site within the Rheinland Refinery Complex.

With a capacity of ten megawatts, this would be the largest unit of its kind in Germany and the world’s largest PEM (Polymer Electrolyte Membrane) electrolyser. This electrolyser technology is also suitable to improve the stability of the electricity grid with a growing share of intermittent renewable energy sources, such as from solar and wind.

The consortium has been invited to the preparation of a grant agreement by the European Fuel Cells and Hydrogen 2 Joint Undertaking (FCH 2 JU), following a competitive call for proposals.

Today, the refinery uses approximately 180,000 tons of hydrogen per year in its various plants. The hydrogen is currently produced as a by-product of the refining process or through natural gas reforming, while electrolysis uses electricity to split water into the base components of hydrogen and oxygen.

The project aims to enable the construction and operation of a large scale10 MW electrolyser that can produce high quality hydrogen and CO2 free hydrogen while demonstrating technology and cost improvements through up-scaling and new business applications. Electrolysis using low-cost renewable electricity could be a key technology for a potential CO2 free hydrogen production in the Shell Rheinland Refinery.

Related Content

  • November 25, 2015
    Next-generation fuel cells ready for low-emission electricity production
    The VTT Technical Research Centre of Finland, under the INNO-SOFC project and in collaboration with Convion and Elcogen, is developing a new-generation, long-life fuel cell system offering efficiency higher than that of competing technologies. The project aims to develop new, energy-efficient and commercially viable applications.
    Read More
  • October 14, 2020
    Birmingham to open Clean Air Zone in 2021
    Hydrogen buses will also start operating in the UK city from next year
    Read More
  • May 24, 2013
    Britain's first Bio-LNG filling station launched
    The UK's first open access Bio-LNG filling station, built by Gasrec , has been launched, marking the start of a nationwide investment in infrastructure seeking the ultimate prize of wiping out nearly two-thirds of the nation's heavy goods vehicle (HGV) emissions. Gasrec's ground-breaking new facility in Daventry is the first of its kind. It will lead to significant cuts in pollution and fuel costs; allow gas-powered or dual-fuel trucks to use Bio-LNG; and will operate in a similar way to a traditional petr
    Read More
  • November 7, 2018
    Wrightbus showcases fuel cell electric bus in the UK
    Wrightbus says its double deck bus uses fuel cell technology to deliver zero emissions while in operation. The StreetDeck fuel cell electric vehicle was displayed at the UK’s Euro Bus Expo 2018 in Birmingham. Fuel cell technology mixes hydrogen and compressed air (oxygen) in a chemical process to generate electric power to drive. The company says the vehicle comes with an extended storage option which increases its range from 200 to 265 miles. Also, the bus can be refuelled in seven minutes. Stre
    Read More

Highlighted Content