Next-generation fuel cells ready for low-emission electricity production

The VTT Technical Research Centre of Finland, under the INNO-SOFC project and in collaboration with Convion and Elcogen, is developing a new-generation, long-life fuel cell system offering efficiency higher than that of competing technologies. The project aims to develop new, energy-efficient and commercially viable applications.
November 25, 2015 Read time: 2 mins

The 814 VTT Technical Research Centre of Finland, under the INNO-SOFC project and in collaboration with Convion and Elcogen, is developing a new-generation, long-life fuel cell system offering efficiency higher than that of competing technologies. The project aims to develop new, energy-efficient and commercially viable applications.

Fuel cells are used to generate low-emission electricity and heat. Thus far, the adoption of such systems into widespread use has been hindered by their short service life and high price. These factors have been made the key development areas of the INNO-SOFC project, which was launched in September and is funded by the EU and managed by VTT. The target is set to double the service life and halve the cost of fuel cell systems and enable the emergence of commercial applications.

VTT, in collaboration with Elcogen and other European partners and Convion, will develop a 50 kW fuel cell system that will have an efficiency of 60 per cent for electricity production and a total efficiency of 85 per cent. Elcogen will deliver the core of the system, the fuel cells. VTT will act as the project coordinator, supporting the R&D of the companies participating in the project and validating the service life of the system and the cells.

The new fuel cell system will generate normal alternating current and will be able to be used in several different applications. Fuel cells can be used to generate electricity and heat from methane produced by biomass at wastewater treatment and biogas plants. In addition to biogas, the distribution of liquefied natural gas will enable the use of fuel cell systems outside the current gas network.

Compared with competing systems, such as generators powered by a combustion engine, fuel cell systems exhibit a high efficiency level, low emissions, low noise and low vibration levels. Improved efficiency is especially pronounced in applications smaller than 1,000kW in power, in which fuel cells may exhibit efficiency double that of competing technologies and produce CO2 emissions that are correspondingly lower. Other emissions, such as particles, nitrogen oxides and noise, also remain at very low levels.

Other participants in the project include Dutch Energy Matters, Italian ENEA, Dutch ElringKlinger and Forschungszentrum Jülich.

The project, which commenced in September 2015, is scheduled for completion in April 2018.

Related Content

  • March 6, 2015
    New range extenders for hybrid electric vehicles in 2015
    According to the IDTechEx report Range Extenders for Electric Vehicles Land, Water & Air 2015-2025, over eight million hybrid cars will be made in 2025, with a range extender, the additional power source that distinguishes them from pure-electric. They will also be in buses, military vehicles and boats: a major new market overall. Today's range extenders consist of little more than off-the-shelf internal combustion engines. They are being replaced by second-generation range extenders - piston engines design
    Read More
  • November 7, 2018
    Wrightbus showcases fuel cell electric bus in the UK
    Wrightbus says its double deck bus uses fuel cell technology to deliver zero emissions while in operation. The StreetDeck fuel cell electric vehicle was displayed at the UK’s Euro Bus Expo 2018 in Birmingham. Fuel cell technology mixes hydrogen and compressed air (oxygen) in a chemical process to generate electric power to drive. The company says the vehicle comes with an extended storage option which increases its range from 200 to 265 miles. Also, the bus can be refuelled in seven minutes. Stre
    Read More
  • April 23, 2012
    Russian researchers to unveil revolutionary fuel cell project
    A state-of-the-art joint project spearheaded by the Tomsk Polytechnic Research University and Icelandic professor, Horsteinn I. Sigfusson, who was awarded the Global Energy International prize in 2007, will be showcased at Russia Day as part of the international exhibition Hannover Messe-2012, which is to be held from 23 to 27 of May, 2012 in Germany.
    Read More
  • September 19, 2017
    New services and equipment helps cities tackle air quality issues
    With poor urban air quality shortening lives and fines being imposed for breaching pollution limits, authorities are seeking ways to clean up their cities. Poor air quality is topping the agenda for city authorities across the globe. In the UK, for example, a report from the Royal Colleges of Physicians and of Paediatrics and Child Health, concluded that poor outdoor air quality shortens the lives of around 40,000 people a year – principally by undermining the health of people with heart and/or lung prob
    Read More

Highlighted Content