Clutchless multi-speed transmission for EVs

Transmission specialist Zeroshift has devised a multi-speed gearbox for electric vehicles (EVs) that needs no clutch.
February 1, 2012 Read time: 1 min
Zeroshift's multi-speed transmission concept changes gear without interrupting the torque, allowing EVs to run for longer at peak efficiency.

Transmission specialist 1994 Zeroshift has devised a multi-speed gearbox for electric vehicles (EVs) that needs no clutch. A damper inside the gear hubs and electronic control of the motor make ratio changes seamless. The company claims the innovation could enable manufacturers to downsize EVs’ electric motors, keeping them running longer at the medium loads and speeds where peak efficiency of over 95 per cent is possible. For drivers, that could mean more performance, greater range and longer lasting batteries.

Zeroshift’s managing director Bill Martin says: “Our studies suggest that by using a compact, multi-speed transmission and a smaller electric motor, manufacturers can gain an operating efficiency of up to 10 per cent. You can use that 10 per cent to improve EVs’ range or reduce the size, weight and cost of battery packs.”

Zeroshift’s concept prevents any torque interruptions during ratio changes and does not require a clutch, issues that have so far deterred EV manufacturers from fitting multi-speed gearboxes. Current EVs instead use a single-speed transmission, but the motor then spends more of its time outside of its optimum efficiency range.

For more information on companies in this article

Related Content

  • Bit by bit insurers agree data protocol
    November 7, 2013
    Telematics technology may be a game changer for the automobile insurance industry but it comes with some caveats as Colin Sowman discovers. James Bielak, (P&C) program manager at the US office of ACORD (the Association for Cooperative Operations Research and Development), has an unenviable job: to devise a standard form of communicating vehicle data between telematics providers and insurance companies. To that end he has gathered together a group composed of insurers, telematics providers and other intere
    Read More
  • Caltrans takes the long view of transport
    October 21, 2016
    Caltrans’ Malcolm Dougherty took time out of his schedule at ITS America 2016 in San Jose to talk to ITS International about current and future challenges. As director of California Department of Transportation (Caltrans) since mid-2012, many would say that Malcolm Dougherty has one of the best jobs in transportation. Caltrans is one of the most progressive and innovative transport authorities, implementing policies to encourage cycling, piloting new
    Read More
  • Ken Leonard talks to ITS International
    August 21, 2014
    Ken Leonard, director of the USDOT’s ITS Joint Program office made time in his schedule during the Helsinki Congress to speak to ITS International. It has been 18 months since Ken Leonard took over as the director of the Intelligent Transportation Systems Joint Program Office at the US Department of Transportation. With 30 years of technical experience behind him, to say he is enjoying the challenge would be to put it mildly: “It is incredibly exciting to be working in intelligent transportation systems, th
    Read More
  • Norwegian study finds electric cars 'pose environmental threat'
    October 5, 2012
    According to a study by the Norwegian University of Science and Technology, electric cars might pollute much more than petrol or diesel-powered cars. Researchers found greenhouse gas emissions rose dramatically if coal was used to produce the electricity. Electric car factories also emitted more toxic waste than conventional car factories, claims their report in the Journal of Industrial Energy. However, in some cases electric cars still made sense, the researchers said.
    Read More

Highlighted Content