Clutchless multi-speed transmission for EVs

Transmission specialist Zeroshift has devised a multi-speed gearbox for electric vehicles (EVs) that needs no clutch.
February 1, 2012 Read time: 1 min
Zeroshift's multi-speed transmission concept changes gear without interrupting the torque, allowing EVs to run for longer at peak efficiency.

Transmission specialist 1994 Zeroshift has devised a multi-speed gearbox for electric vehicles (EVs) that needs no clutch. A damper inside the gear hubs and electronic control of the motor make ratio changes seamless. The company claims the innovation could enable manufacturers to downsize EVs’ electric motors, keeping them running longer at the medium loads and speeds where peak efficiency of over 95 per cent is possible. For drivers, that could mean more performance, greater range and longer lasting batteries.

Zeroshift’s managing director Bill Martin says: “Our studies suggest that by using a compact, multi-speed transmission and a smaller electric motor, manufacturers can gain an operating efficiency of up to 10 per cent. You can use that 10 per cent to improve EVs’ range or reduce the size, weight and cost of battery packs.”

Zeroshift’s concept prevents any torque interruptions during ratio changes and does not require a clutch, issues that have so far deterred EV manufacturers from fitting multi-speed gearboxes. Current EVs instead use a single-speed transmission, but the motor then spends more of its time outside of its optimum efficiency range.

Related Content

  • Cooperative systems and privacy not mutually exclusive
    February 1, 2012
    Are co-operative systems and personal privacy mutually exclusive? Not necessarily, says Neil Hoose. But the more advanced the application, the greater the concession of privacy may have to become. ITS Stockholm in 2009 and the Cooperative Mobility Showcase event which took place alongside Intertraffic in Amsterdam in March this year both featured live, on-street demonstrations of safety and driver information applications that used Vehicle-to-Infrastructure (V2I) and Vehicle-to-Vehicle (V2V) communications,
    Read More
  • Cooperative systems and privacy not mutually exclusive
    February 6, 2012
    Are co-operative systems and personal privacy mutually exclusive? Not necessarily, says Neil Hoose. But the more advanced the application, the greater the concession of privacy may have to become
    Read More
  • ASECAP examines tolling’s trials, tribulations and triumphs
    September 4, 2018
    If you want to get up to speed on the main issues facing the transport sector and tolling companies, ASECAP Study Days event in Ljubljana was a good place to start. Colin Sowman reports (Photographs: Louis David). Increasing populations, ever-higher technical and safety requirements, and electric and hybrid vehicles will provide both challenges and opportunities for tolling companies. The annual Study Days event organised by ASECAP (the European association for tolling companies) examined all of these aspec
    Read More
  • IRD complements WIM with tyre under-inflation detection
    May 8, 2015
    To complement its existing WIM offering, IRD has introduced a system to detect under-inflated and flat tyres at highway speeds. Tyre inflation pressure has both safety and economic impacts for road users and none more so than with commercial vehicles. An underinflated tyre has decreased directional control, increased risk of catastrophic failure, and negatively impacts tyre life and fuel economy. In June 2014 the USDOT published Large Truck and Bus Crash Facts 2012 in which the Federal Motor Carrier Safety
    Read More

Highlighted Content