Siemens’ Plus+ simplifies signalised intersection wiring

The latest innovation from Siemens comes under the Plus+ banner and encompasses its third generation digitised traffic control system which features distributed intelligence and simplifies cabling. In place of up to 300 wire cores on a single signalised intersection, the Plus+ system uses just four cables arranged in a system of rings, arms and spurs. The four wires, two power (48V) and two data, are used to connect ‘intelligent nodes’ in each traffic light head to be connected to the central controller, re
June 2, 2017 Read time: 2 mins
The latest innovation from 189 Siemens comes under the Plus+ banner and encompasses its third generation digitised traffic control system which features distributed intelligence and simplifies cabling.


In place of up to 300 wire cores on a single signalised intersection, the Plus+ system uses just four cables arranged in a system of rings, arms and spurs. The four wires, two power (48V) and two data, are used to connect ‘intelligent nodes’ in each traffic light head to be connected to the central controller, retaining functionality while minimising wiring and greatly simplifying installation.

Beyond reducing the ducting requirements to a single duct for each run, the ring configuration means that if a cable is severed the power and data can flow the ‘other way’ round the ring to reach the controller and therefore minimise or eliminate outages.  And if a traffic light pole is knocked over, the head(s) it carries will be automatically isolated, allowing the remaining lights to function as normal.

Cost reductions of up to 20% are possible and many existing sensors (loops, push button and so on) can be connected to the system.

The company is already working on pre-wiring traffic light heads in order that electrical installation at the roadside is reduced to connecting only four wires.

Urban Traffic Control

For more information on companies in this article

Related Content

  • Healthy prospects for floating vehicle data systems
    February 3, 2012
    Elmar Brockfeld, Alexander Sohr and Peter Wagner from the German Aerospace Center's Institute of Transport Systems look at the prospects for floating vehicle data systems. Although Floating Vehicle Data (FVD) or probe vehicle fleets have been around for about a decade, the idea behind them is of course much older: from probe vehicles that flow with the traffic it should be possible to get a precise, fast and spatially near-complete picture of the prevailing traffic flow conditions in an area under surveilla
    Read More
  • European tunnel safety steps up a gear
    September 19, 2017
    David Crawford reviews the latest safety systems installed in European tunnels. Blueprints for the safer road tunnels of the future are emerging fast as European operators invest in technologies to enhance travellers’ prospects of surviving an accident. Central to modern emergency planning is the principle that, following an incident, drivers should be enabled to rescue themselves and their passengers with the aid of prompt and correct identification and communication of the hazard. Roles for cooperativ
    Read More
  • Siemens Mobility is clearing the air
    October 2, 2020
    Tens of thousands of premature deaths in the UK alone are linked to air quality - but it doesn’t have to be that way. Siemens Mobility’s Wilke Reints explains why
    Read More
  • The need for a higher voltage power net for vehicles
    June 27, 2012
    Electrification of the automobile is not limited to the electric vehicles (EVs). As a new report from Frost & Sullivan points out, conventional cars of today are partly electric in their own way, with most systems in the vehicle having electrical and electronic connections for better functionality. Certain high-end vehicles possess more than 90 electronic control units (ECUs) to control the various modules within the car, making the car both sophisticated and complicated. However, added functions such as el
    Read More

Highlighted Content