Skip to main content

Vehicle to improve safety and reduce disruption on motorways

Inspired by the aviation industry, a new vehicle developed by Highways England to help replace overhead signs is set to reduce the duration of roadworks. The vehicle is based on the design of an aircraft catering vehicle, which loads refreshments into aeroplanes using a hydraulic scissor lift. Traditionally, signs are taken down and installed using a flat-bed truck, crane and cherry picker, taking up to 40 minutes. However the new Maintenance Assistance Vehicle (MAV) can do this in around 20 to 25 min
May 26, 2016 Read time: 2 mins
Inspired by the aviation industry, a new vehicle developed by 8101 Highways England and Mott MacDonald to help replace overhead signs is set to reduce the duration of roadworks.

The vehicle is based on the design of an aircraft catering vehicle, which loads refreshments into aeroplanes using a hydraulic scissor lift.

Traditionally, signs are taken down and installed using a flat-bed truck, crane and cherry picker, taking up to 40 minutes. However the new Maintenance Assistance Vehicle (MAV) can do this in around 20 to 25 minutes by using a small jib crane which is part of the vehicle.

Road workers will also be able to shut fewer lanes using the MAV, which has been successfully trialled on the roads. The device also provides a safer environment for road workers while they work inside the vehicle - and on a sturdy platform while they work outside it.

Once the platform is raised to a sufficient height, the jib crane carefully attaches to the sign on the gantry and lifts it off.  The operatives then detach the sign, place it onto a trolley on the platform, and wheel it into the main compartment of the vehicle. The procedure is reversed when installing a new electronic sign.

The hydraulically powered scissor lift enables the signs, which are often found on smart motorway gantries, to be serviced at heights of up to 8.5 metres and in wind speeds of up to 47mph. Furthermore, its CCTV cameras, which play a critical safety role, enable the driver to park the vehicle in exactly the correct place below the gantry before any maintenance takes place and monitor the operatives at the back while they work.

Highways England is currently examining the best way for its contractors to purchase the machines. It is estimated that if the device was widely adopted it could save up to US$6 million (£4 million) a year.

Consideration is also being given as to whether it could be used to improve safety for other duties on England’s motorways and major A roads.

For more information on companies in this article

Related Content

  • Solar road studs aid night time road safety on the M20
    October 23, 2012
    UK company, Astucia, part of the Clearview Traffic Group, and Balfour Beatty Mott MacDonald has installed over 4,000 Astucia SolarLite road studs on the M20 junctions 8 to 9 between Ashford and Maidstone, on behalf of the UK Highways Agency. This section of the motorway lacks street lighting increasing the potential risk for night time accidents. The project involved upgrading the existing road markings and road studs to address the high number of collisions recorded in the dark and wet conditions. The exis
  • Just Zip it! Lindsay takes to the road
    October 10, 2018
    Greater vehicle connectivity is going to have huge implications for traffic management. David Arminas climbed aboard a Lindsay Road Zipper to see what this might mean in future As vice president of barrier specialist QMB Canada, Marc-Andre Seguin is sanguine about the future for moveable barriers. On the one hand, it looks good. The oft-stated advantage of moveable barriers is that the systems are cheaper to install than adding a lane or two to a highway or bridge. Directional changes to lanes can boost
  • Autoflight demos air taxi in China 
    February 28, 2022
    The vertical flight for the Prosperity I required eight rotors to lift the 3,307 pounds
  • ‘Formation flying’ engineering trains used to upgrade railway
    February 16, 2017
    In a bid to increase efficiencies and reduce delays for passengers, the UK’s Network Rail is trialling ‘formation flying’ engineering trains to repair and renew the 20,000 miles of railway track it is responsible for maintaining. It says this new approach to engineering could potentially save taxpayer-funded Network Rail US$313,000 (£250,000) per week in costs by allowing trains to run at higher speeds once engineering is complete. The pioneering technique was used successfully at Sandy, Bedfordshire, on