Skip to main content

Vehicle to improve safety and reduce disruption on motorways

Inspired by the aviation industry, a new vehicle developed by Highways England to help replace overhead signs is set to reduce the duration of roadworks. The vehicle is based on the design of an aircraft catering vehicle, which loads refreshments into aeroplanes using a hydraulic scissor lift. Traditionally, signs are taken down and installed using a flat-bed truck, crane and cherry picker, taking up to 40 minutes. However the new Maintenance Assistance Vehicle (MAV) can do this in around 20 to 25 min
May 26, 2016 Read time: 2 mins
Inspired by the aviation industry, a new vehicle developed by 8101 Highways England and Mott MacDonald to help replace overhead signs is set to reduce the duration of roadworks.

The vehicle is based on the design of an aircraft catering vehicle, which loads refreshments into aeroplanes using a hydraulic scissor lift.

Traditionally, signs are taken down and installed using a flat-bed truck, crane and cherry picker, taking up to 40 minutes. However the new Maintenance Assistance Vehicle (MAV) can do this in around 20 to 25 minutes by using a small jib crane which is part of the vehicle.

Road workers will also be able to shut fewer lanes using the MAV, which has been successfully trialled on the roads. The device also provides a safer environment for road workers while they work inside the vehicle - and on a sturdy platform while they work outside it.

Once the platform is raised to a sufficient height, the jib crane carefully attaches to the sign on the gantry and lifts it off.  The operatives then detach the sign, place it onto a trolley on the platform, and wheel it into the main compartment of the vehicle. The procedure is reversed when installing a new electronic sign.

The hydraulically powered scissor lift enables the signs, which are often found on smart motorway gantries, to be serviced at heights of up to 8.5 metres and in wind speeds of up to 47mph. Furthermore, its CCTV cameras, which play a critical safety role, enable the driver to park the vehicle in exactly the correct place below the gantry before any maintenance takes place and monitor the operatives at the back while they work.

Highways England is currently examining the best way for its contractors to purchase the machines. It is estimated that if the device was widely adopted it could save up to US$6 million (£4 million) a year.

Consideration is also being given as to whether it could be used to improve safety for other duties on England’s motorways and major A roads.

For more information on companies in this article

Related Content

  • Making roads safer with IRD’s TACS
    November 16, 2020
    Since IRD introduced its Tire Anomaly and Classification System (TACS) a few years ago, it has been widely adopted for tyre safety screening.
  • Balfour Beatty and Mott MacDonald secure contract expansion for Area 10
    October 17, 2017
    Highways England has awarded a £115 million ($152 million) asset support contract extension of 17 months to Balfour Beatty and Mott MacDonald to continue its service delivery for Area 10; covering Merseyside, Cheshire, Lancashire and Greater Manchester. The contract will run from November 2017 to March 2019. The current asset support contract delivers a range of service delivery and maintenance activities such as 24/7 incident response, to ensuring the safe operation of the 570km of the road network.
  • German authorities use CB-radio message to reduce accidents in roadworks
    April 8, 2014
    Citizen Band radio is proving useful to prevent accidents in Germany’s roadworks. In common with other German Länder (federal regions) with large volumes of commercial vehicles using their trunk road networks, Bavaria had been experiencing high levels of road traffic accidents (RTAs) involving heavy trucks in the vicinity of minor motorway maintenance sites. This was despite the extensive visual warning regulations published in the German federal road safety audit (RSA) guidelines for the protection of site
  • Refurbishing ageing VMS with new technology
    January 26, 2012
    Virginia DoT faced a challenge common to many highway authorities around the world: the need, in economically challenging times, to replace ageing variable message signs reaching the end of their operational life. For some 25 years now, since the mid 80s, Virginia Department of Transportation (VDoT), has deployed variable message signs (VMS) as part of its motorist information systems. Throughout the state there are still many old 'flip-disk' signs. Some of the companies that provided these electronic messa